Ford Mondeo since 2000
1. Introduction
2. Equipment
3. Care of the car
4. Engines
5. Greasing system
6. Cooling system
7. System of injection of fuel
8. Ignition system
9. Fuel system
9.1. Fuel
9.2. Check of ventilation and tank airing
9.3. Replacement of the fuel filter (the petrol engine)
9.4. Replacement of the fuel filter (the diesel engine)
9.5. Опорожнение a tank – patient game without the fuel pump, demanding sleight of hand
9.6. Dismantle of pipelines and hoses (the general instructions)
9.7. Search of malfunctions of the fuel pump
9.8. Dismantle and installation of the fuel pump (the petrol engine)
9.9. System of release of the fulfilled gases
9.10. Councils for work with an exhaust system
9.11. A cost question – a complete repair or partial replacement
9.12. The poorly fulfilled gas - ASU
9.13. Neutralisation of the fulfilled gases
10. Transmission
11. A running gear
12. Brake system
13. The electrotechnical equipment
14. Electroschemes
15. Car salon
16. A body
17. Technical characteristics
18. The help at malfunctions
 



ba88fb63



9-4-zamena-toplivnogo-filtra-dizelnyjj-dvigatel.html

9.4. Replacement of the fuel filter (the diesel engine)

 PERFORMANCE ORDER

    Disconnect wires from the storage battery. Cautiously release топливопроводы on the case of the filter and merge fuel following under pressure. Dismantle the fuel filter. Merge the remained fuel and utilise as a special waste. Before installation of the new filter fill in the case with pure diesel fuel. Tighten all pipelines and... ... Connect the accumulator. Include ignition for approximately 30 seconds and...

    Circulation of diesel fuel on топливопроводам:

    1 — the Pipeline to the electropump,
    2 — the Pipeline to the fuel filter,
    3 — the Drain pipeline to a tank,
    4 — the Drain pipeline to the filter,
    5 — the Adjusting valve.

    ... Start then the engine and let it idles until will earn exactly. During this procedure diesel engine Mondeo is automatically ventilated. Check up all connections and a filter flange on tightness.

Linkage of a water condensate – diesel fuel

Diesel fuel possesses bad property to absorb in itself a water condensate and to spend with itself polluting particles. Therefore it is necessarily necessary to observe the ordered interval of replacement of the fuel filter or to spend its change after a long trip to a non-European zone. Unfortunately, earlier used dehydrating valves in modern diesel filters even more often get out of fashion, so the filter case already does not dry any more and the condensate does not merge any more.


«The previous page
9.3. Replacement of the fuel filter (the petrol engine)
The following page»
9.5. Опорожнение a tank – patient game without the fuel pump, demanding sleight of hand